气固循环床上行两相流颗粒曳力系数研究

黄卫星; 诸海碧; 黎梅

您当前的位置：

首页 >

文章列表页 >

气固循环床上行两相流颗粒曳力系数研究

化学工程 | 更新时间：2023-11-28

- 气固循环床上行两相流颗粒曳力系数研究
- Drag Coefficient in Gas solid Two Phase Flow of CFB Riser
- 工程科学与技术 2008年40卷第2期页码：53-57
- 作者机构：
  
  四川大学化工学院四川,成都,610065
- 作者简介：
- 基金信息：
  
  国家自然科学基金——海外杰出青年学者基金资助项目（29928005）
- DOI：
  中图分类号：
- 纸质出版日期：2008，
扫描看全文
黄卫星,诸海碧,黎梅.气固循环床上行两相流颗粒曳力系数研究[J].工程科学与技术,2008,40(2):53-57.

Drag Coefficient in Gas solid Two Phase Flow of CFB Riser[J]. Advanced Engineering Sciences, 2008,40(2):53-57.
黄卫星,诸海碧,黎梅.气固循环床上行两相流颗粒曳力系数研究[J].工程科学与技术,2008,40(2):53-57. DOI：

Drag Coefficient in Gas solid Two Phase Flow of CFB Riser[J]. Advanced Engineering Sciences, 2008,40(2):53-57. DOI：

摘要

中文摘要: 在高16 m气-固循环流化床提升管内，通过测定表观气速、颗粒质量流率和不同轴向高度的床层平均颗粒浓度，结合对单颗粒进行受力平衡分析，间接获得了不同轴向位置的颗粒曳力系数。同时通过分析雷诺数、阿基米德数、床层颗粒浓度对颗粒曳力系数的影响，结合实验中所获得的数据，提出颗粒曳力系数的关联式。该关联式考虑颗粒的物性参数、操作条件对曳力系数所造成的影响，其预测值与本文和文献实验值吻合良好，并且在一维轴向均相模型下较好预测了床层内轴向压力分布。

Abstract

Abstract:Systematic experiments were carried out in a 16 m high gas solid CFB riser with FCC particles to investigate the drag force acted on solids by gas. Based on the measured data of the cross sectional average solids holdups at different axial locations of riser under various operation conditions and through the dynamic balance analysis of single particle

drag coefficients were indirectly obtained. The results show that the solids holdups have great effect on drag coefficients

which obviously decrease with increasing solids holdups. Considering the effects of Reynolds number

Archimedes number and solids holdups

a new correlation for drag coefficients was developed. The predicted values of the new correlation for drag coefficients were compared with the experimental data of this work and some other authors

and a good agreement was observed for three different particles. Using the drag coefficient correlation

the axial pressure gradients of gas solid flow in riser are successfully predicted.

关键词

循环流化床提升管气固两相流曳力系数

Keywords

circulating fluidized bedsrisergas solid flowdrag coefficient

references

Li Jie,Kuipers J A M.Gas-particle interactions in dense gas-fluidized beds[J].Chem Eng Sci,2003,58:711-718.

Yasuna J A,Moyer H R,Elliott S,et al.Quantitative predictions of gas-particle flow in a vertical pipe with particle-particle interactions[J].Powder Technology,1995,84(1):23-24.

Ergun S.Fluid flow through packed columns[J].Chemical Engineering and Processing,1952,48:49.

Wen C Y,Yu Y H.Mechanics of fluidization[J].AIChE J,1966,62:100.

Bai Dingrong,Jin yong,Yu zhiqing.The particle acceleration and the interaction between gas and solids in the riser of circulating fluidized beds[J].Chemical Reaction Engineering and Technology,1991(7):260-270.[白丁荣,金涌,俞芷青.循环流化床内颗粒的加速作用及气固两相间的动量交换[J].反应工程与工艺,1991(7):260-270.]

Mostoufi N,Chaouki J.Prediction of effective drag coefficient in fluidized beds[J].Chem Eng Sci,1999,54:851-858.

Brucato A,Grisafi F,Montante G.Particle drag coefficients in turbulent fluids[J].Chem Eng Sci,1998,53:3295-3314.

Makkawi Y T,Wright P C.The voidage function and effective drag force for fluidized beds[J].Chem Eng Sci,2003,58:2035-2051.

Mabrouk R,Chaouki J,Guy C.Effective drag coefficient investigation in the acceleration zone of an upward gas-solid flow[J].Chem Eng Sci,2006,62:318-327.

Zhang H,Johnston P M,Zhu J X,et al.A novel calibration procedure for a fiber optic solids concentration probe[J].Powder Technology,1998,100:260-272.

Littman H,Morgan M H III,et al.Effect of particle diameter,particle density and loading ration on the drag effective drag coefficient in steady turbulent gas-solids transport[J].Powder Technology,1995,84:49-56.

Felice R D.The voidage function for fluid-particle interaction systems[J].International Journal of Multiphase Flow,1994,20:153.

Qi Xiaobo,Zeng Tao,Huang Weixing.Experimental study of solids holdups inside particle clusters in CFB risers[J].Journal of Sichuan University:Engineering Science Edition,2005,37:46-50.[漆小波,曾涛,黄卫星.循环流化床提升管中团聚物颗粒浓度的试验研究[J].四川大学学报:工程科学版,2005,37:46-50.]

Qi Xiaobo,Huang Weixing.Radial distribution and axial development of particle velocities in a long CFB riser[J].Chinese J of Chem Eng,2002,16:168-173.[漆小波,黄卫星.循环流化床提升管中颗粒速度的径向分布及其沿轴向的发展[J].化工学报,2002,16:168-173.]

浏览量

360

下载量

CNKI被引量

文章被引用时，请邮件提醒。

提交

工具集

关联资源

暂无数据